2 Years ago this Month - December

Some pictures from December, 2010 from the wonderful islands in the Sea of Cortez.


2 Years ago this Month - November

In this continuing series of where we were two years ago, here's a few pictures from November 2010 during the Baja Haha and as we made our way up into the Sea of Cortez.

Panga at Bahia Santa Maria

Crazy in Cabo

Huge, out of place Hotel in Cabo

The Friars at Bahia Los Frailes

Jane'O at anchor in Ballandra Bay

A visitor in La Paz


2 Years ago this Month - October

Here's a few pictures from October 2010 of Catalina and the start of the Baja Haha.

Two Harbors mooring field

Two Harbors mooring field

Cat Harbor

Jane'O at the start of the Baja Haha (photo credit unknown)

Valparaiso at the Haha start (photo credit unknown)

Some great sailing shots off San Diego


2 Years ago this Month - September

We thought it would be fun to post some pictures of where we were two years ago each month for the next six months - during our trip from California to Mexico and back.

Well, I know it's a bit into October, but I'm going to kick this off with a few pictures from September 2010 that we never posted before. Enjoy!

Chris and Jacob on a nice walk along the ocean.

Jane'O in Monterey

The crazy birds in Port San Luis

This boat looks forlorn now, but it's the Gentry Eagle - which holds the record for crossing the Atlantic Ocean  in 62 hours. She now sits in Ventura, converted to a luxury yacht and awaiting a new owner.


New house battery bank installation

This weekend we installed a new house battery bank for Jane'O. The old batteries, which are probably around 10 years old have been on their last legs for quite some time. Although they were still working, they weren't delivering anywhere near their original 430Ah, but at their age they don't owe anyone any favors and have far outlasted any reasonable expectations.

We're big believers in flooded 6V golf cart batteries connected series-parallel to create a 12V bank for house batteries. Nothing can beat them for cost per Ah, and as long as they are cared for and never discharged below around 50%, they last a very long time. The big problem for flooded lead-acid batteries is they require maintenance - namely, topping off regularly with distilled water. On Jane'O, while our batteries aren't horribly inaccessible, getting in to where the batteries are to see the water level and top them off to the right level is difficult enough that we admit to not taking very good care of them.

Another reason to stick with old-school flooded batteries - although Gel and AGM batteries require no maintenance, you can't mix different types of batteries on a single charging system - which means we would not only have to change out the engine and generator starting batteries, but also have to recalibrate our battery monitor, AC charging system, and both engine alternator regulators to the different type of batteries. And these batteries can be 2 to 3 times the cost of golf cart batteries.

While doing some research on which batteries to use, we came across battery watering systems that make topping off the water of every battery as simple as connecting a single tube and waiting a minute or two - and the entire bank is topped off to the right level every time. While not a cheap system, it was a no brainer for us, that should ensure our new bank lasts at least as long as the old one.

So, this was the right choice for us - replace the existing 4 golf cart batteries with 4 new ones, and install a watering system to keep the water levels properly maintained. We also replaced all the battery cross-connect cables, as the old ones were, well... old... and some of the crimps had started to loosen. 

We went with US Battery 2200XC batteries, which are 232Ah at 6V each, giving a total bank capacity of 464Ah at 12V - slightly higher than the old batteries, but not by much. They were purchased from a local golf cart shop, making it easy and relatively cheap. These are off the shelf batteries using standard battery posts - which means they are available anywhere. The only thing I had to do to the battery monitor was give it the new total bank capacity, and set the Peukert Exponent for these batteries. No changes to the charger or engine alternator regulators was needed.

As far as the battery cable cross-connects go, instead of connecting a single cable for each series pair, as is commonly done (and was the previous configuration), we instead cross-connected them as suggested by Nigel Calder.

This is the common way that a series-parallel connection is done, but it can cause one of the series pairs to work harder than the other, especially if something goes wrong with one of the series jumpers (this actually happened to us in Mexico). Forgive my butchering, as well as copying Mr. Calder's drawings without his consent.

The usual cross-connect method
Compare with the below. This is the way Nigel Calder suggests making the cross connects, which helps balance all batteries in the bank. Also note that positive and negative cables should always come off opposite corners, again to keep individual batteries balanced.

A better cross-connect method

These drawings are copied from Nigel Calder's excellent book "Boatowner's Mechanical And Electrical Manual". 

Here's a few pictures of the installation, including the battery watering system and making the new cross-connects.

Crimping a lug with an excellent, but overpriced Ancor crimping tool using a vice

Completed cross-connects, 1/0 cable with adhesive heat-shrink

New battery, note the SpeedCap, which is about to be removed for the watering caps

The white SpeedCap has been replaced with three black watering caps

The bank nearly ready to be installed, staged in the cockpit with the same spacing as it will have in the engine roon

Watering tank, filled with distilled water

Flow indicator. When this doohickey stops spinning, the batteries are ready to go

Installed bank. Note the blue connector in the upper left for the watering tank. There is some non-ideal wiring here because of too many things wired directly to the bank, a project we need to fix someday (some self-inflicted, some inherited from previous owners)

Tired old batteries and cables. Note that one of the cross-connects was simply taped with blue tape, instead of done with adhesive heat-shrink


Neat Chart Plotter App for Android - MX Mariner

Recently I stumbled across MX Mariner, a nifty chart plotter app for Android phones and tablets. This is well worth checking out, and it's only $7 in the Android app store.

While pretty new and still under active development, MX Mariner is better than nearly every other marine charting app in the Android store - and certainly nothing can beat it at this price. Many charting apps are impractical for real use as they require a live and fast data connection, they require saving charts one-by-one in advance, or they don't support chart quilting at all. With MX Mariner, you download a region when you have a good wifi connection - these are big files, 150-250MB, but once you have the file for a region, MX Mariner will automatically quilt charts for that reason as you navigate - and no data connection is required! Note that switching to Google Earth view does require an active data connection, but since the primary point of this is for marine charts, that's reasonable.

Some features, like GPX import/export are still under development, expect to see new features soon! Like OpenCPN, MX Mariner embraces iterative development, and you can even contribute if you so desire. If you notice some similarities between OpenCPN and MX Mariner, that's no accident - as the primary developer of MX Mariner is also a contributor of OpenCPN.

Currently, MX Mariner has somewhat limited world coverage, take a look at the website for more details.

So, if you are looking for an Android based chart plotter app, give this one a try! It works great on our Samsung Galaxy-S phone, and HTC Flyer 7" tablet. Looking forward to see what features come next!
Click here to buy Jane'O merchandise